（1） Cooling system

發電機的連續使用會使其各部件被加熱。所以靜音型發電機組有一個冷卻和通風系統的用于排除工作過程中產生的熱量。

The continuous use of a generator will cause its various components to be heated. So the silent generator set has a cooling and ventilation system to eliminate the heat generated during operation.

淡水有時被用作冷卻發電機，但是有很大的局限性，只適用于特定的設備如小型發電機。在商業應用或大型機組超過2250千瓦及以上時。乙二醇用于大型發電機組定子繞組冷卻液因為比其他冷卻劑它可以更有效地吸收的熱量。這就是為什么大型發電機和小型發電廠經常有大型冷卻塔在旁邊。其他常見的應用，住宅和工業，一個標準的散熱器和風扇安裝在發電機可以作為初級冷卻系統。每天檢查發電機的冷卻水是至關重要的一項工作。冷卻系統及原水泵應每600個小時后進行更換使用，發電機換熱器應每2400個小時后運行清洗。發電機應放置在一個開放的、通風的地方，有足夠的新鮮空氣供應。

Fresh water is sometimes used for cooling generators, but it has significant limitations and is only suitable for specific equipment such as small generators. When in commercial applications or large units exceeding 2250 kilowatts or above. Ethylene glycol is used as a coolant for large generator stator windings because it can more effectively absorb heat than other coolants. That's why large generators and small power plants often have large cooling towers next to them. For other common applications, residential and industrial, a standard radiator and fan installed on a generator can serve as a primary cooling system. Checking the cooling water of the generator every day is a crucial task. The cooling system and raw water pump should be replaced and used every 600 hours, and the generator heat exchanger should be cleaned every 2400 hours. The generator should be placed in an open and ventilated area with sufficient fresh air supply.

(二)排氣系統

（2） Exhaust systehttp://linshi2.weidaoshang.com/機組發電機在運行過程中會產生大量的廢氣，像任何其他的柴油或汽油發動機排氣都含有劇毒的化學物質，需要進行適當的管理。因此，安裝適當的排氣系統由于廢氣處理是必不可少的一項工作。排氣管通常由鑄鐵、鍛鐵或鋼構成。這些需要是獨立的，不應該由發電機的引擎支持。排氣管通常連接方式采用柔性連接器，這樣可以減少振動，防止發電機損壞發動機的排氣系統。排氣管避免對著其他建筑，應直接排向戶外。你必須確保你的發電機排氣系統沒有連接到任何其他設備。但是你必須要遵守當地的環保要求，因為排氣是一項污染較大的工作。

Silent generator sets generate a large amount of exhaust gas during operation, which, like any other diesel or gasoline engine exhaust, contains highly toxic chemicals and requires appropriate management. Therefore, installing an appropriate exhaust system is essential as exhaust gas treatment is an essential task. The exhaust pipe is usually composed of cast iron, forged iron, or steel. These need to be independent and should not be supported by the engine of the generator. The exhaust pipe is usually connected using flexible connectors, which can reduce vibration and prevent the generator from damaging the engine's exhaust system. The exhaust pipe should avoid facing other buildings and should be directly discharged outdoors. You must ensure that your generator exhaust system is not connected to any other equipment. But you must comply with local environmental requirements, as exhaust is a highly polluting job.

潤滑系統

lubrication system

由于發電機包括發動機的運動部件，都需要潤滑工作，這樣才能保證長時間的耐久性和流暢的操作。發電機的發動機潤滑油儲存在一個潤滑油泵中。你每8小時就應該檢查發電機潤滑油系統以保證機組的正常運行。你也應該檢查是否有泄漏的潤滑油，當機組連續工作500小時后，潤滑油應該進行更換，這樣可以保證潤滑油的清潔性。

Due to the fact that the generator, including the moving parts of the engine, requires lubrication in order to ensure long-term durability and smooth operation. The engine lubricating oil of the generator is stored in a lubricating oil pump. You should check the generator lubricating oil system every 8 hours to ensure the normal operation of the unit. You should also check for any leaking lubricating oil. After the unit has been operating continuously for 500 hours, the lubricating oil should be replaced to ensure its cleanliness.

電池充電器

Battery charger

靜音型發電機組發電機的啟動功能是電池操作的。如果浮動電壓很低，電池不足以支持發電機的啟動。如果浮充電壓很高，會縮短電池的壽命。電池充電器通常采用不銹鋼，這樣具有很強的防腐蝕性能。他們也都是全自動的，不需要做任何調整或改變任何設置。

The starting function of the silent generator set generator is battery operated. If the floating voltage is very low, the battery is not sufficient to support the start of the generator. If the float charging voltage is high, it will shorten the battery life. Battery chargers are usually made of stainless steel, which has strong corrosion resistance. They are also fully automatic and do not need to make any adjustments or change any settings.

有了工業尾氣發電機組上面的小總結，希望對廣大客戶有所幫助，如果有什么不理解的或者尋求幫助的請點擊我們的網站：http://www.qmtg666.com或者來電咨詢，我們會盡全力為您解決

With the summary above for industrial exhaust gas generator sets, we hope it can be helpful to our customers. If you have any questions or need help, please click on our website: http://www.qmtg666.com Or call for consultation, and we will do our best to solve it for you